Tesla TI4676 Manual do Utilizador

!"#$%&'%()$&*+",'%()$)-&./Tesla Industries Inc.109 CenterPoint Blvd.New Castle, DE 19720(302)324-8910 Phone(302) 324-8

2-47) Replace thewhite clip back intothe fuse clip. Takecare not to damagethe tabs.8) Completely insertwhite clip in to fuseclip (GENTLY) untilit snap

CHAPTER 3OPERATING LIMITS AND RESTRICTIONSSECTION I. GENERAL3-1. PURPOSEChapter 3 includes all important operating limits and restrictions thatmust b

3-4. 120-240 50/60 Hz VAC CHARGER AND AC TO DC CONVERTER LIMITSThe unit is designed with a single point AC receptacle for externalpower to operate b

AC Line Cords North American Old British U.K Cont. Europe (more examples in appendix or call factory for information)CAUTION*8

3-8. CONTINUOUS OUTPUT RATE, 28.5 VDC CONSTANT OUTPUT35 Amps at 1 hour (with AC power connected)NOTEIf current demand exceeds 12 amps, converter out

CAUTIONUnit may be damaged if operated when unit’s cold or heat soaked tem-perature exceed the specified limit. If unit is operated when cold orheat

WARNING********SHOCK HAZARD POTENTIAL*********Severe injury, or Death, from electrical shock is possible when person-nel and/or TI4676 are wet during

CAUTIONUnit damage may occur if inlet and outlet vent ports are obstructedand/or cooling airflow is restricted. Back Vent Side Ve

CHAPTER 4OPERATING AND INSTALLATION PROCEDURESSECTION I. UNIT INSTALLATION4-1. INSTALLATION1. Remove original aircraft battery and dispose of properl

SECTION II. OPERATING PROCEDURES (cont.)4-5. OPERATING PROCEDURESThis section deals with normal procedures, and includes all steps nec-essary to ensu

WARNING*******SHOCK HAZARD POTENTIAL*******IMPROPER USE/FAILURE TO FOLLOW INSTRUCTIONS IN OPERATORS MANUAL CAN RE-SULT IN UNIT FAILURE AND/OR POSSIBLE

CAUTIONREMEMBER, when the AC line cord is plugged in, the unit must be placedin a position to allow the cooling fan to operate properly!Unit may over

CAUTIONUnit may overheat if cooling fan fails.Do not operate if cooling fan fails.2. CHECK FOR FULL CHARGE INDICATION - After 1 HR 15 minutes, LEDcha

SECTION III.FUNCTIONAL CHECK PROCEDURES AND TROUBLE SHOOTING4-8. FUNCTIONAL CHECK PROCEDURESThis section deals with normal functional check procedure

7. CHECK DC VOLTAGE READING AT DC RECEPTACLE TERMINALS. Ensure powercells are fully charged (see step 6.)28.5 (±0.57 VDC) with power cells at full s

CHAPTER 5PERFORMANCE DATASECTION 1. INTRODUCTION5-1. PURPOSEThis chapter provides performance data for the TI4676. Continual refer-ence to this info

SECTION IIDATA CRITERIA5-3 DATA BASISThe type of data used is indicated at the bottom of each performancechart under DATA BASIS. The applicable repor

FIGURE 5-15-3

FIGURE 5-25-4TI4676MPU-24 OUTPUT VOLTAGEOUTPUT VOLTAGEMINUTES23 AMP CONSTANT CURRENT LOAD24201612840010 2030405060

MAXIMUM OUTPUT CURRENTAMPSCalculation based on actual test data at Pratt-Whitmey on 30 March 1992SECONDS1500135012001050900750600450150300005101520253

CHAPTER 6CARE AND MAINTENANCESECTION I. UNIT CARE6-1. GENERAL Although the TI4676 has been ruggedized and made weather resistantwithin the scope of

TABLE OF CONTENTSTITLE PageCHAPTER 1 INTRODUCTION 1-1CHAPTER 2 UNIT DESCRIPTION AND OPERATION

Chapter 7Push To Test ModificationGeneral Information And Operation7-1. GeneralTHIS MODIFICATION HAS BECOME STANDARD EQUIPMENT FOR EACH OF OURUNITS.

PARAGRAPH INDEX120-240 50/60 Hz VAC Charger and AC to DC Converter Limits, 3-4Abbreviations, 1-5AC Power Cord Limits, 3-5After Use, 6-2Appendix A

PARAGRAPH INDEXIndex, 1-4Installation, 4-1Maintenance of Unit, 6-3Maximum Output Current, Figure 5-3One (1) Hour Rate, 24 VDC Constant Output, 3-6

APPENDIX AOPTIONAL LINE CORDS FOR WORLDWIDE OPERATIONSCOUNTRY VOLTS HZ TESLA PART #Afganistan 220 50 TI25000-004 Old British Lin

APPENDIX A (Cont.)OPTIONAL LINE CORDS FOR WORLDWIDE OPERATIONSCOUNTRY VOLTS HZ TESLA PART #Ecuador 120 60 TI25000-001 North Amer

APPENDIX A (Cont.)OPTIONAL LINE CORDS FOR WORLDWIDE OPERATIONSCOUNTRY VOLTS HZ TESLA PART #Laos 220 50 TI25000-001 North America

APPENDIX A (Cont.)OPTIONAL LINE CORDS FOR WORLDWIDE OPERATIONSCOUNTRY VOLTS HZ TESLA PART #Romania 220 50 TI25000-003 Cont. Euro

A-5APPENDIX A (Cont.)UNIVERSAL LINE CORD KIT FOR WORLDWIDE OPERATIONSNOTE: TESLA UNIVERSAL AC LINE CORD KIT, P/N: TI25000-U00, IS FORUNITS ORIGINALLY

CHAPTER 1INTRODUCTION1-1. GENERALThese instructions are for use by the owner/operator. They apply tohandling and operation of the TI4676 Micro Power

1-4. INDEXThe index lists, in alphabetical order, every titled paragraph and fig-ure contained in this manual.1-5. ABBREVIATIONS AND SYMBOLSAbbrevia

1-6. FORMS AND RECORDSNONE REQUIRED.1-7. USE OF WORDS SHALL, SHOULD, AND MAY.Within this technical manual the word “shall” is used to indicate amand

CHAPTER 2UNIT DESCRIPTION AND OPERATIONSECTION I. UNIT2-1. GENERALThe TI4676 (Figure 2-1) is a compact, portable and highly versatile 24/28.5 VDC ele

WARNING Check fuse holder window to ensure the fuse setting reads either120 or 240 prior to connecting recharge cord to AC power source. Fusesetting

!"#$%&'!"#